Comparative Evaluation of Physicochemical and Bioactive Properties of Adansonia digitata Seed Roasted Brew from Selected Zimbabwean Locations and Roasting Conditions

Kelvin Magava

doi:10.70851/jfines.2026.3(4).277.288

Authors

Kelvin S. Magava Chinhoyi University of Technology Author https://orcid.org/0009-0008-0628-7977

DOI:

https://doi.org/10.70851/jfines.2026.3(4).277.288

Keywords:

bioactive compounds, Adansonia digitata, Functional beverage, Geographical origin, Physicochemical properties

Abstract

The increasing demand for functional foods has stimulated interest in underutilized indigenous resources with potential nutritional and health benefits. This study comparatively evaluated the physicochemical and bioactive properties of A. digitata seed roasted brew prepared from selected Zimbabwean locations under different roasting conditions. Baobab seeds collected from three ecologically distinct regions of Zimbabwe, Manicaland, Masvingo, and Mashonaland East were roasted at 150 °C, 175 °C, and 200 °C, representing light, medium, and dark roasts, respectively. Brewed samples were evaluated for physicochemical attributes (pH, titratable acidity, moisture content, total soluble compounds, viscosity, crude fibre, and sugar concentration) and bioactive properties (total phenolics, flavonoids, antioxidant activity and caffeine content). Variation in the measured parameters was observed across the roasting temperatures and selected locations investigated. The 175 °C roasting condition produced comparatively favourable values for several measured physicochemical and bioactive characteristics. Masvingo samples exhibited the highest total phenolic content (4.39 ± 0.12 mg GAE/g), total flavonoid content (9.39 ± 0.26 mg RE/g), and DPPH radical scavenging activity (77.69 ± 3.60%), indicating potential for functional beverage production. In contrast, Manicaland samples showed higher moisture content and comparatively lower antioxidant constituents, while Mashonaland East samples retained higher crude fibre levels. Caffeine was not detected in the analysed samples under the analytical conditions employed. Overall, the findings demonstrate variation in the physicochemical and bioactive characteristics of A. digitata seed roasted brew across the selected locations and roasting conditions, while sensory responses varied across the geographical samples evaluated at 175 °C. The results provide preliminary evidence supporting further investigation of baobab seed as a potential raw material for development of alternative roasted beverages. Further studies using multiple independent biological lots from each location are recommended to establish the reproducibility and broader applicability of these observations

References

Abbasi, A. M., Guo, X., & Chen, Y. (2024). Functional Properties of Foods and Beverages. Foods, 13(17), 2763.

Asogwa, I. S., Ibrahim, A. N., & Agbaka, J. I. (2021). African baobab: Its role in enhancing nutrition, health, and the environment. Trees, Forests and People, 3, 100043.

Benmeziane-Derradji, F., Djermoune-Arkoub, L., Ayat, N. E. H., & Aoufi, D. (2020). Impact of roasting on the physicochemical, functional properties, antioxidant content and microstructure changes of Algerian lentil (Lens culinaris) flour. Journal of Food Measurement and Characterization, 14(5), 2840-2853.

Chen, X., Shuai, C., & Wu, Y. (2023). Global food stability and its socio‐economic determinants towards sustainable development goal 2 (Zero Hunger). Sustainable Development, 31(3), 1768-1780.

Dado, T. (2020). Determination and characterization of caffeine content of small and large size coffee beans in sidama and kambata tambaro zones southern, ethiopia using uv-vis spectrophotometer. INTERNATIONAL JOURNAL, 11(7), 1084-1196.

Das, P. P., Duarah, P., & Purkait, M. K. (2023). Fundamentals of food roasting process. In High-Temperature Processing of Food Products (pp. 103-130). Woodhead Publishing.

Donno, D., & Turrini, F. (2020). Plant foods and underutilized fruits as source of functional food ingredients: Chemical composition, quality traits, and biological properties. Foods, 9(10), 1474.

Elsayed, M. E., Abdalhameed, H. A., Eltahir, M. E., Adam, I., Sulieman, I., Abdalgader, A., ... & Musa, F. I. (2023). Uses, Harvesting, Consumption of Baobab Leaves, Pulps and Seeds in North and West Kordofan States Sudan. Journal of Global Agriculture and Ecology, 20-28.

Farah, A. (2019). Flavor development during roasting. In Drying and Roasting of Cocoa and Coffee (pp. 267-309). CRC press.

Fischer, S., Jäckering, L., & Kehlenbeck, K. (2020). The baobab (Adansonia digitata L.) in southern Kenya–a study on status, distribution, use and importance in Taita–Taveta County. Environmental management, 66(3), 305-318.

Foltz, M., Zahradnik, A. C., Van den Abbeele, P., Ghyselinck, J., & Marzorati, M. (2021). A pectin-rich, baobab fruit pulp powder exerts prebiotic potential on the human gut microbiome in vitro. Microorganisms, 9(9), 1981.

Gao, P., Wang, S., Feng, B., Liu, C., Wang, Y., Dou, S., & Dong, L. (2025). Volatile profiling from thermal decomposition of Amadori compounds in the alanine-glucose Maillard reaction: An DFT insight of 3-ethyl-2, 5-dimethylpyrazine forming mechanism. Food Chemistry: X, 102446.

Gebre, T. S., Emire, S. A., Aloo, S. O., Chelliah, R., Vijayalakshmi, S., & Oh, D. H. (2024). Unveiling the potential of African fermented cereal-based beverages: Probiotics, functional drinks, health benefits and bioactive components. Food Research International, 114656.

Ghafoor, K., Ahmed, I. A. M., Özcan, M. M., Al-Juhaimi, F. Y., Babiker, E. E., & Azmi, I. U. (2020). An evaluation of bioactive compounds, fatty acid composition and oil quality of chia (Salvia hispanica L.) seed roasted at different temperatures. Food Chemistry, 333, 127531.

Grzelczyk, J., Fiurasek, P., Kakkar, A., & Budryn, G. (2022). Evaluation of the thermal stability of bioactive compounds in coffee beans and their fractions modified in the roasting process. Food chemistry, 387, 132888.

Gulcin, İ., & Alwasel, S. H. (2023). DPPH radical scavenging assay. Processes, 11(8), 2248.

Gupta, A., Sanwal, N., Bareen, M. A., Barua, S., Sharma, N., Olatunji, O. J., ... & Sahu, J. K. (2023). Trends in functional beverages: Functional ingredients, processing technologies, stability, health benefits, and consumer perspective. Food Research International, 170, 113046.

Ismail, B. B., Guo, M., Pu, Y., Wang, W., Ye, X., & Liu, D. (2019). Valorisation of baobab (Adansonia digitata) seeds by ultrasound assisted extraction of polyphenolics. Optimisation and comparison with conventional methods. Ultrasonics Sonochemistry, 52, 257-267.

Ismail, B. B., Huang, R., Liu, D., Ye, X., & Guo, M. (2022). Potential valorisation of baobab (Adansonia digitata) seeds as a coffee substitute: Insights and comparisons on the effect of roasting on quality, sensory profiles, and characterisation of volatile aroma compounds by HS-SPME/GC–MS. Food Chemistry, 394, 133475.

Lamidi, W. A., Ogunlade, C. A., Olaniyan, A. R., Shittu, K. A., Murtadha, M. A., Ajibade, A. F., & Fadeyibi, A. (2023). Moisture dependent: physical properties of baobab seeds (Adansonia digitata L.). Agricultural Engineering, 27.

Lopes, G. R., Petronilho, S., Ferreira, A. S., Pinto, M., Passos, C. P., Coelho, E., ... & Coimbra, M. A. (2021). Insights on single-dose espresso coffee capsules’ volatile profile: from ground powder volatiles to prediction of espresso brew aroma properties. Foods, 10(10), 2508.

Lu, T., Sun, Y., Huang, Y., & Chen, X. (2023). Effects of roasting on the chemical compositions, color, aroma, microstructure, and the kinetics of changes in coffee pulp. Journal of Food Science, 88(4), 1430-1444.

Magava, K., Nomathemba, C., Tawanda, C., & Tanaka, M. (2026). Geo-Nutritional Variability of Baobab (Adansonia digitata) Seeds across Diverse Agro-Ecological Zones in Zimbabwe: Insights into Macro-nutrients, Micro-nutrients and Anti nutritional Factors. Journal of Food Innovation, Nutrition, and Environmental Sciences, 3(1), 32-45.

Mahmud, M. C., Shellie, R. A., & Keast, R. (2020). Unravelling the relationship between aroma compounds and consumer acceptance: Coffee as an example. Comprehensive Reviews in Food Science and Food Safety, 19(5), 2380-2420.

Meinhold, K., & Darr, D. (2022). Keeping up with rising (quality) demands? The transition of a wild food resource to mass market, using the example of baobab in Malawi. Frontiers in Sustainable Food Systems, 6, 840760.

Mohamed Ahmed, I. A., Değerli, Z., Özcan, M. M., & Babiker, E. E. (2023). Effect of different oil extraction methods on bioactive compounds, antioxidant capacity and phytochemical profiles of raw flaxseeds (Linum usitatissimum) and after roasting at different temperatures. Journal of the Science of Food and Agriculture, 103(14), 7117-7126.

Musyoki, J. K., Kaigongi, M. M., Uchi, S. M., Kiama, S. M., Githiomi, J., Muthike, G. M., & Luvanda, A. M. (2022). Distribution and population status of Adansonia digitata L.(baobab) and its contribution to livelihood in Makueni County, Kenya. Trees, Forests and People, 8, 100270.

Nyoni, M., Mahuni, C., Ngirande, C., Sithole, M. N., Mukoko, F. T., Tavengana, E. V., ... & Muzerengwa, R. (2024). The Untapped Potential of Wild and Underutilized Fruits in the Development of Novel Commercial Products in Africa. In Food Security and Nutrition (pp. 382-398). CRC Press.

Offiah, V. O., & Falade, K. O. (2023). Potentials of baobab in food systems. Applied Food Research, 3(1), 100299.

Omotayo, A. O., & Aremu, A. O. (2020). Underutilized African indigenous fruit trees and food–nutrition security: Opportunities, challenges, and prospects. Food and Energy Security, 9(3), e220.

Oyesiji, O. O., Ologunde, M. O., Adewole, S. A., Alawode, O. W., & Adesola, M. O. (2020). Nutritional evaluation of baobab seed protein extract and its potential as a component of weaning Food. J. Food Chem. Nanotechnol, 6(2), 72-77.

Patra, M., Bashir, O., Amin, T., Wani, A. W., Shams, R., Chaudhary, K. S., ... & Manzoor, S. (2023). A comprehensive review on functional beverages from cereal grains-characterization of nutraceutical potential, processing technologies and product types. Heliyon, 9(6).

Petisca, C., Pérez-Palacios, T., Farah, A., Pinho, O., & Ferreira, I. M. (2013). Furans and other volatile compounds in ground roasted and espresso coffee using headspace solid-phase microextraction: Effect of roasting speed. Food and Bioproducts Processing, 91(3), 233-241.

Prieto, P., Pineda, M., & Aguilar, M. (1999). Spectrophotometric quantitation of antioxidant capacity through the formation of a phosphomolybdenum complex: specific application to the determination of vitamin E. Analytical biochemistry, 269(2), 337-341.

Przybylska-Balcerek, A., Frankowski, J., & Stuper-Szablewska, K. (2020). The influence of weather conditions on bioactive compound content in sorghum grain. European Food Research and Technology, 246(1), 13-22.

Shakoor, A., Zhang, C., Xie, J., & Yang, X. (2022). Maillard reaction chemistry in formation of critical intermediates and flavour compounds and their antioxidant properties. Food Chemistry, 393, 133416.

Sharma, N., Yeasmen, N., Dube, L., & Orsat, V. (2024). A review on current scenario and key challenges of plant-based functional beverages. Food Bioscience, 104320.

Silva, M. L., Rita, K., Bernardo, M. A., Mesquita, M. F. D., Pintão, A. M., & Moncada, M. (2023). Adansonia digitata L.(Baobab) bioactive compounds, biological activities, and the potential effect on glycemia: a narrative review. Nutrients, 15(9), 2170.

Taş, N. G., & Gökmen, V. (2017). Maillard reaction and caramelization during hazelnut roasting: A multiresponse kinetic study. Food chemistry, 221, 1911-1922.

Vinha, A. F., Costa, A. S., Pimentel, F. B., Espírito Santo, L., Sousa, C., Freitas, M., ... & Oliveira, M. B. P. (2024). Bioactive compounds and scavenging capacity of Adansonia digitata L.(baobab fruit) pulp extracts against ROS and RNS of physiological relevance. Applied Sciences, 14(8), 3408.

Wangiyana, I. G. A. S., & Triandini, I. G. A. A. H. (2025). Sensory evaluation of tea with different brewing conditions: a systematic review of recent 10-year studies. Journal of Agritechnology and Food Processing, 5(2).

Wondimkun, Z. T., Jebessa, A. G., Molloro, L. H., & Haile, T. (2016). The determination of caffeine level of wolaita zone, Ethiopia coffee using UV-visible spectrophotometer. American Journal of Applied Chemistry, 4(2), 59-63.

Yadav, D. S., Jaiswal, B., Gautam, M., & Agrawal, M. (2020). Soil acidification and its impact on plants. In Plant responses to soil pollution (pp. 1-26). Singapore: Springer Singapore.

Yakubu Baban Kanada, B. M., Maina, M., & Kauji, A. M. (2024) Determination of some Essentials Element in Baobab Powder from Damaturu Local Government area of Yobe State Nigeria.

Yan, X. T., Zhang, Z., Wang, Y., Zhang, W., Zhang, L., Liu, Y., ... & Gu, R. (2023). Antioxidant capacity, flavor and physicochemical properties of FH06 functional beverage fermented by lactic acid bacteria: a promising method to improve antioxidant activity and flavor of plant functional beverage. Applied Biological Chemistry, 66(1), 7.